SAN FRANCISCO (AP) -- The pilot of an empty oil tanker that crashed into the San Francisco-Oakland Bay Bridge was involved in three previous accidents, records obtained Tuesday show.
Pilot Guy Kleess was held responsible for two of the accidents and ordered to undergo more training after a ship he was piloting damaged a dock in Stockton in 2009, according to records from the state Board of Pilot Commissioners.
The disclosure came as two federal agencies and the state board pursued investigations of the crash of the 752-foot tanker Overseas Reymar.
The U.S. Coast Guard classified the accident as a "major marine casualty" because it exceeded $500,000 in property damage. However, no oil leaks were reported and the bridge remained open. No crew members were injured.
Coast Guard Petty Officer Pamela J. Boehland said investigators interviewed Kleess on Tuesday. The ship's master — or captain — and key crewmembers were also interviewed.
She also said no alcohol was found in any of the critical crew members tested, including Kleess. Boehland said investigators are still analyzing samples for drug use.
Human error is one factor being explored by the Coast Guard as a possible cause of the crash. Visibility at the time was about a quarter-mile, but officials didn't say if that was a factor.
The National Transportation Safety Board said it will coordinate its investigation with the Coast Guard and proceed in light of safety recommendations made after another tanker, the Cosco Busan, hit a nearby tower on the same bridge in 2007 and spilled 53,000 gallons of oil into the bay.
The state board licensed Kleess in 2005 after he completed a two-year training program and joined an elite cadre of mariners who are required by state law to guide every large vessel in the San Francisco Bay and other Northern California waterways.
Board records show Kleess was involved in three prior shipping accidents. He was found at fault in two of the incidents, and all were considered minor, agency chief Allen Garfinkle said.
"They in no way reflect on his skill," Garfinkle said.
Kleess was held blameless when the bow of a ship he was piloting in the Sacramento River on Aug. 27, 2009, "took a sudden sheer to the left" and ran into the bank at slow speed, according to a report to the Legislature.
Two days later, Kleess was found at fault when a ship he was piloting damaged a dock in the Port of Stockton. No damage estimate was provided for repairing a wooden pylon used to support a catwalk.
Kleess agreed to undergo four training runs in the narrow and shallow inland waterways that Garfinkle said are the toughest routes for pilots to navigate.
"Only our most elite pilots go up there," Garfinkle said. "It takes a special person to do that type of work."
The commissioners' 2010 annual report showed Kleess also was held responsible for allowing a ship he was piloting on May 26, 2010, to stray into shallow water in the Richmond Inner Harbor, causing a tug boat tending the ship to briefly run aground. The board found there was minimal damage and Kleess wasn't disciplined for the incident.
Other agency records also showed that pilot Guy Kleess was placed on medical leave in August 2010 for an undisclosed ailment. His license expired in November of that year. The Coast Guard cleared him for duty, and his license was renewed on Jan. 11, 2011, minutes of a monthly meeting of the pilot commissioners show.
A call to Kleess' San Francisco home on Tuesday went unanswered.
Board records show Kleess went to work on oil tankers for Exxon Oil Co. after graduating from the United States Merchant Marine Academy in 1976.
The company promoted him several times during the next 13 years. He ultimately attained the rank of master — or captain — of his own ship. He held various other high-ranking mariner positions with other companies before entering the San Francisco Bay bar pilots training program in 2003.
Investigators also will inspect the hull above and below the water line, but Lansing said it wasn't breached.
The bridge sustained minor damage and remained open after the accident that damaged 30 to 40 feet of "fender" material that will need to be replaced.
The fender system made of steel and wooden timbers was built onto the west span to absorb such strikes.
OSG Ship Management Inc., the parent company that owns the Marshall Islands-registered Overseas Reymar, said the accident occurred as the vessel hit an underwater portion of the massive bridge structure. The ship was not carrying oil as cargo, only fuel to power its engines, Goodyear said.
The crew reported no loss of steering or propulsion, and initial investigations showed no water leaks from any of the ballast tanks, said Darrell Wilson, a spokesman for OSG.
California Emergency Management Agency spokesman Jordan Scott said the superstructure of the bridge was fine.
Associated Press writers Lisa Leff, Sudhin Thanawala and Terence Chea contributed to this report.