By Carey Gillam and P.J. Huffstutter
TEXHOMA, OKLAHOMA/CHICAGO (Reuters) - On the windswept prairies of the Oklahoma Panhandle, the hog barns of Prestage Farms are lined up like military barracks. The 20,000-sow operation near the Texas border stands at the front lines of a months-long battle to contain a virus that has already killed some 1.3 million hogs in the United States.
Since June, when Porcine Epidemic Diarrhea virus, or PEDv, first hit, Prestage workers have quarantined the area, scrubbed vehicles and sprayed buildings with antiseptic. But those precautions have not stopped a virus that can kill 80 percent of piglets that contract it.
"In the blink of an eye, 30,000 pigs were dead," said John Prestage, senior vice president at Prestage, describing the first wave of devastation the virus brought to its Oklahoma operation, which raises and sells 400,000 hogs a year.
The outbreak is spreading. And researchers have discovered evidence that the virus - which poses no threat to humans - can be carried on the wind, potentially bringing a dangerous new dimension to the swine epidemic.
More than 600 cases, each of which could represent thousands of infected animals, have been reported in 17 states. If research confirms that the disease can be transmitted through the air, it would heighten concern about controlling the outbreak.
Some farmers may have fewer healthy animals to send to slaughter this fall and winter. Consumers, too, could feel the pinch if smaller supplies and forecasts of a 10 percent jump in cash hog prices later this year translate to higher prices at the grocery meat counter.
Mystery surrounds the virus, which first cropped up in Europe in the 1970s and remains uncontrolled in China and other parts of Asia nearly four decades after it first appeared. In the United States, which discovered its first-ever case in April, the outbreak of the heat-sensitive virus slowed this summer as temperatures rose and weakened the spread. But PEDv is expected to thrive again as the weather cools, and airborne transmission could further the virus's reach.
Previously, scientists had found the swine virus was transmitted only by physical contact, or carried in on dirty boots or contaminated equipment. But new research shows the virus can be carried through the air on dried fecal matter, even though scientists say the virus has not mutated. The strain making its way across the nation's hog farms and slaughterhouses is 99.4 percent similar in genetic structure to the PEDv that hit China's herds last year, according to the U.S. researchers.
Indeed, farmers and pork processors in Oklahoma have told Reuters they now suspect the virus is traveling through the air.
One scientist likened this to the way the deadly Avian influenza has traveled on feathers and fecal dust. That influenza virus has so far killed poultry by the millions and more than 300 people in 13 countries, according to World Health Organization data.
"There is a chance that airborne contaminated feces may have played a role in the rapid dissemination" of the virus, particularly in Oklahoma, said Dr. Montserrat Torremorell, who is leading research efforts on the outbreak at the University of Minnesota's College of Veterinary Medicine.
Researchers at Minnesota's veterinary diagnostic lab found the virus in air samples taken by Seaboard Foods
Pigs injected with samples of the virus collected by Seaboard Foods did not contract the disease, Torremorell said. But she still believes airborne distribution may be a threat. "I would not rule it out," she said.
Seaboard, in a statement to Reuters, said it provided samples "to university swine health experts to investigate and determine the nature of the virus." The company would not say how many of its piglets have died because of PEDv.
Federal investigators have traced the first U.S. case to Ohio in mid-April but so far have not pinpointed the origin of the coronavirus that causes PEDv or how it entered the United States. Farmers, veterinarians and laboratory researchers have offered theories ranging from vaccine suppliers to vitamin mix distributors to the pipettes used to inseminate sows.
All agree PEDv's mortality rate is astounding: between 80 percent to 100 percent of very young animals. Most of these piglets die within 72 hours from dehydration associated with diarrhea. Older animals usually survive after being ill.
Officials from the Agriculture Department say they cannot offer a sound estimate on mortality rates, as farmers are not required to report to authorities when there is a PEDv outbreak on their operations.
Eric Neumann, a swine epidemiology expert at Massey University EpiCentre in New Zealand, told Reuters he used data released by federal investigators - and has pegged the death toll at 1.3 million pigs and climbing.
As of the week of September 8, there have been 612 confirmed cases reported in 17 states, according to federal officials. So far, Iowa, the largest U.S. hog producer with 20 million hogs, has reported 181 cases, the most of any state. Oklahoma is second with 155, and Kansas had 77 reported cases.
Researchers are closely watching North Carolina, the nation's second-largest hog state, where 40 cases have been reported since the week of June 23.
To combat the disease, farmers are taking precautions in their handling of animals. Hog producers that use the manure on their own crop fields are searching for ways to get rid of the PEDv, while some grain farmers are hunting for PEDv-free manure for their spring planting.
The government will provide a better gauge of the impact of the outbreak on the nation's pork supply next week, when the USDA releases its quarterly hogs and pigs report. It will offer a look at the nation's swine inventory over the past three months, when the number of positive cases soared.
The market could begin to feel any loss of supplies by October, say industry analysts, when piglets first infected in April would have come to market.
While the death of 1.3 million piglets would represent only about 1 percent of the average annual U.S. slaughter of 113 million, these hogs would have gone to market during a concentrated, four-month stretch starting this fall.
As a result, said University of Missouri livestock economist Ron Plain, the number of hogs slaughtered during that time could drop by 3 percent or more. Live hog prices, which normally plummet in the fall and early winter, could rise by as much as 10 percent, he said.
Even so, both these forecasts - and the number of reported cases - may fall short of capturing the total impact of PEDv. Diagnostic veterinarians say farmers have been under-reporting PEDv cases, either out of fear or resignation. Dead piglets, too, can be disposed of without attracting much notice.
"The farther we get into the outbreak, the less likely the numbers are reflecting what is happening in the country," said Tom Burkgren, executive director of the American Association of Swine Veterinarians.
FEAR AND LOATHING
Oklahoma, a leading pork producer and supplier of piglets to some of the Midwest's largest farms, offers a snapshot of the toll PEDv is taking on the U.S. heartland.
At Hitch Enterprises' hog farms in Guymon, production manager Mike Brandherm said he lost roughly three weeks of production this summer, about 18,000 pigs. At Prestage's Texhoma unit along the Oklahoma-Texas border, manager Greg Stephens told Reuters he is concerned piglets still are dying at an above-normal rate. Sows pass immunity to their newborn, he said, and the piglets should have developed immunity by now.
Just north of the state line, in southwestern Kansas, third-generation hog farmer Nathan Smith is battling the virus by removing young pigs early from farrowing barns and keeping buildings warmer than usual. He also has switched to an organic nutritional supplement to quell diarrhea in the animals.
Smith took action after losing 15,000 piglets this summer, or about $1 million worth of livestock.
"We had this one trailer come back from the packing house, and that started it," he said. "On a Friday, one
Smith is convinced the wind carried the virus. "It moved too fast for tires, too fast for feet," he said. "The only thing that touched each